Must green-tipped fluorescent bulbs be managed as universal waste or can they be managed as municipal waste? Can they be broken to facilitate consolidation for disposal?
Not all lamps are hazardous wastes and those that are not may be disposed of in municipal waste management facilities. It is the responsibility of the generator of the lamp to determine whether it is a hazardous waste.One way to make the determination is through the Toxicity Characteristic Leaching Procedure (TCLP). The TCLP attempts to replicate the conditions in a municipal landfill to detect the mercury concentration of water that would leach from the landfill.
If the mercury concentration exceeds 0.2 milligrams per liter (mg/L), the lamp fails the toxicity test and must be managed as a hazardous waste (or as a universal waste). If the TCLP analysis puts the mercury below the 0.2 mg/L maximum concentration limit, the lamp does not have to be managed as a hazardous waste or a universal waste.
Need an answer fast? Relax. Our editors guarantee a personalized response to your questions within 3 business days. Take a free trial of Enviro.BLR.com and see what everyone is talking about. For a limited time, also receive the new free special report: 2011-2012 EHS Salary Guide. Download Your Free Report
The amount of mercury in a low-mercury bulb can range from 3.5 to 4 milligrams compared to a standard fluorescent bulb which ranges from 8 to 14 milligrams of mercury. These lamps may be identified by green end caps (often referred to as green-tipped lamps), or green etchings on the lamps.
Some generators have found that an analysis that costs only a few hundred dollars saves their facility several thousand dollars a year in disposal/recycling costs. EPA notes, however, that mercury-containing lamps often fail the TCLP and that the test results can vary considerably, depending on the lamp manufacturer, the age of the lamp, and the laboratory procedures used.
EPA encourages the recycling of all mercury-containing lamps, regardless of the mercury content. According to EPA, if you do not test your low-mercury lamps and prove them non-hazardous, then you should assume they are hazardous waste and handle them accordingly.
Under the federal requirements, both small and large quantity generators are required to handle universal waste lamps as follows:
- Contain any lamp in containers or packages that are structurally sound, adequate to prevent breakage, and compatible with the contents of the lamps.
- Containers and packages must remain closed and must lack evidence of leakage, spillage or damage that could cause leakage under reasonably foreseeable conditions.
- Immediately clean up and place in a container any lamp that is broken or any lamp that shows evidence of breakage, leakage, or damage that could cause the release of mercury or other hazardous constituents to the environment. These containers must be closed, structurally sound, compatible with the contents of the lamps and must lack evidence of leakage, spillage or damage that could cause leakage or releases of mercury or other hazardous constituents to the environment under reasonably foreseeable conditions.
Forget expensive calls to lawyers and consultants. With Enviro.BLR.com, you get instant access, 24/7. Try it out today and get the 2011-2012 EHS Salary Guide, absolutely free. Download Your Free Report
The federal universal waste rule does not specifically address whether lamps can be intentionally broken to facilitate consolidation for disposal or recycling. EPA does note, however, that handlers who choose to intentionally crush lamps must do so in accordance with authorized state programs.
EPA is concerned because crushing or breaking lamps can release mercury into the air and pose a health problem if not appropriately done or if those involved in crushing the lamps do not have the appropriate protective equipment. Check with your state to determine their requirements for crushing or breaking lamps.
EPA does not regulate the crushing of lamps unless theprocess is done to contaminate the environment.
Keep in mind that a worker crushing lams could easily exposed to mercury during the process of crushing and placing the crushed lamps in a proper container. EPA does not have jursidiction. OSHA does.